I do wish we had not lost out ability to drink salt water, or breath it for that matter.   It was an unfortunate turn in our evolutionary path.  And wouldn’t it be very advantageous for sailors to also have a monkey’s tail?

So how do we manage to survive on an ocean of poison and avoid drinking our own urine?   We need a least a gallon a day of fresh water.  Much more to live in the comfort.   Part of the problem is our idea of clean water.  For too many of us we believe that it only comes from a plastic bottle.   Rivers, streams, ice, snow, and even rain have been placed on the “Dangerous” list.    Putting rain water on the “You can’t drink that”  list is nothing short another bad choice on evolutionary path.

So on Seeker our primary source of fresh water will be rain water.  The pilot house and cabin tops are all built to collect rainwater.  The drain hoses that collect the water from each corner will be routed to dump the water over board, but that water will fist pass through a ball valve.  Once the majority of salt and bird shit have washed over the side the valves will be closed and the water will back up in the hose to a Tee where it will find a new route into our holding tanks built into the cargo holds floor.  Once these tanks full the excess wash through the tanks and dump the excess into the bilge in order to turn over the water in the tanks.

But is does not always rain and fresh water tanks can be contaminated by accidents so we need another reliable source.  Reverse Osmosis or simply forcing sea water through a membrane that forces the salt out of the solution is a popular solution.   And for the most part it is a reliable solution.   However distillation is another solution and it has some attractive advantages for a boat that wants to operate cheap and be able to make it’s own repairs even while at sea.

 

 

http://www.maximevaporators.com/heat-recovery-evaporators

Heat Recovery Evaporator

Cody McMillan a Chief Engineer in the Canadian Coast Guard sent me this photo.  It is a flash evaporator on a 72 foot trawler. built 1968, still works like a dream today. the only thing they have done since the 60’s is to add an electric pre heat and a salinity meter.  Heater in the bottom from the engine, condenser in the top, vacuum pump to lower the boiling temp of the water.  Sea water is pumped in, evaporated then condensed in the top and pumped out. this unit makes about 150 gallons an hour.

The warmer the sea water going into it, the more efficiently it works.  The added inline pre heater for the sea water gets it up to about 35C before it hits the evaporator. At full vacuum the waterinside boils at about 60C

The vacuum pump is also the brine pump.  It draws water in through an orifice and the pump is designed to run dry and pump air as well as water, so the pump suction is at a set point to flood the lower chamber. so it maintains the level inside the chamber as well as drawing it into a vacuum.

What We Want in a Water Maker

A flash evaporator is the basic water maker I want for Seeker, but I want to develop plans for unit that we can build and maintain on-board without complicated parts.  And one that can also make some water passively with a small pump and solar or stove heating.   And I want it tied in with a hot water supply system as well as a radiator heating system.   A water maker that can provide small quantities of water is that it can operate without the necessity or reliance on an engine.   Fewer dependencies in any system is a better system in my book.  And as it will be able to generate great quantities of water when powered off the main or auxiliary engine; we will be able to provide water of a number of people when the need arises.  And by building the unit ourselves we will be able to pass alone a low cost design to others.

 

Starter idea from Bob Gaston:

 

Any solar or wind generating system you need a dump so that you do not over charge your batteries, this is where the 12v 300 watt heater comes in.  Refrigeration unit can still be used for other purposes (beer,food,air conditioning)   The heat from the refrigeration unit is used as a preheat.  The heat from the engine would be more efficient if taken from the exhaust. My thinking is for the heat from the engine and the heat from the solar share the same heat exchanger at the distillation unit that way only require one circulation pump.  — Bob

 

 

 

Resources:
Maxium, Submarine Distilling Systems, Alfa Laval, SondexGenerating Drinking Water on Ship